6165con登录平台

欢迎光临山汽集团企业官网!
400-879-1999
在线购机
点击拨打服务热线:400-879-1999
您现在所在的位置: 6165con登录平台> 6165con登录平台常识 > 企业资讯 >
站内搜索
6165con登录平台常识
关于山汽

联系人:刘老师

电话:400-879-1999

企业:山东山汽工程机械(集团)有限企业

地址:山东省莱州市206国道与308省道交叉口东南50米

混凝土搅拌车做到安全行车需要做自身的调整吗?

所属分类:企业资讯 发布时间:2021-08-23 来源:/ 浏览量:18

第一、输送混凝土的容量,质量及塌落度应符合混凝土行业标准和要求。
First, the capacity, quality and slump of transported concrete shall meet the concrete industry standards and requirements.
第二、在混凝土运输过程中罐体禁止停转,防止造成混凝土的凝结,停转重启时会造成对液压系统、减速机的冲击,导致液压泵和马达的损坏。
Second, it is forbidden to stop the tank during concrete transportation to prevent concrete condensation. When stopping and restarting, it will cause impact on the hydraulic system and reducer, resulting in damage to the hydraulic pump and motor.
第三、在公路上行驶时,加长溜槽必须放置在卸料溜槽支架上并用挂钩挂牢,不允许挂在主排料溜槽上运行;主排料溜槽要旋转到固定位置,拉下定位手柄,用锁紧手柄将弹簧变幅机构锁止,防止由于不固定而摇摆,造成伤人事故和影响其它车辆运行可能。
Third, when driving on the road, the extended chute must be placed on the support of the discharge chute and hung firmly with a hook. It is not allowed to hang on the main discharge chute for operation; The main discharge chute shall be rotated to a fixed position, the positioning handle shall be pulled down, and the spring luffing mechanism shall be locked with the locking handle to prevent swinging due to non fixation, causing injury accidents and affecting the operation of other vehicles.
6165con登录平台
第四、工作装置连续运转时间不应超过8h。
Fourth, the continuous operation time of the working device shall not exceed 8h.
第五、卸料时,如发现水分蒸发,塌落度偏低不能满足用户要求时,可适当向筒内加水,然后以10—14r/min的速度旋转30转后卸料,使混凝土充分搅拌。
Fifth, during unloading, if water evaporation and low slump are found, which can not meet the user's requirements, water can be added to the cylinder appropriately, and then rotate at the speed of 10-14r / min for 30 revolutions before unloading, so as to fully mix the concrete.
第六、搅拌车在空载运行过程中,搅拌筒不得停转以免颠簸时造成滚道和托轮局部磕碰,导致托轮和滚道的异常损坏。
Sixth, during the no-load operation of the mixer truck, the mixing drum shall not stop running, so as to avoid local collision between the raceway and the supporting wheel during bumping, resulting in abnormal damage to the supporting wheel and the raceway.
第七、水箱的水量要经常加满,以备急用。水箱加水前,必须打开放气阀把箱内空气放掉;冲洗时打开气阀,冲洗完毕或者停用时应将水罐内气体放掉。冬季停放时,水箱和供水系统里,不得有剩余水,防止冻裂。注意:水箱仅在供水时加压,不要带着加压水箱在公路上行驶。
Seventh, the water tank should always be filled up for emergency use. Before adding water to the water tank, the vent valve must be opened to release the air in the tank; Open the air valve during flushing, and discharge the gas in the water tank after flushing or shutdown. When parking in winter, there shall be no residual water in the water tank and water supply system to prevent frost cracking. Note: the water tank is pressurized only when supplying water. Do not drive on the road with the pressurized water tank.
第八、满载混凝土正转,如要反转,必须操纵手柄使正转停稳后,再操纵手柄反转。严禁正转过程中操纵手柄使其反转。
Eighth, full load concrete forward rotation, if you want to reverse, you must operate the handle to make the forward rotation stop stably, and then operate the handle to reverse. It is strictly prohibited to operate the handle to reverse it during forward rotation.
本文由6165con登录平台奉献.更多有关的常识请点击:真诚的态度.为您提供为全面的服务.更多有关的常识大家将会陆续向大家奉献.敬请期待.
This paper is composed of automatic concrete mixer Dedication. For more relevant knowledge, please click: sincere attitude. Provide you with comprehensive service. More relevant knowledge will be offered to you one after another. Please look forward to it
热门产品 / HOT PRODUCT
4.0方6165con登录平台
推荐产品

4.0方6165con登录平台

3.5方B款6165con登录平台
推荐产品

3.5方B款6165con登录平台

3.5方B款6165con登录平台
推荐产品

3.5方B款6165con登录平台

4.0方6165con登录平台
推荐产品

4.0方6165con登录平台

2方后置驾驶室6165con登录平台
推荐产品

2方后置驾驶室6165con登录平台

3.5吨C款
推荐产品

3.5吨C款

6.5方6165con登录平台
推荐产品

6.5方6165con登录平台

2.6方同步旋转6165con登录平台
推荐产品

2.6方同步旋转6165con登录平台

4方同步旋转6165con登录平台
推荐产品

4方同步旋转6165con登录平台

3.5方A款6165con登录平台
推荐产品

3.5方A款6165con登录平台

4.0方全自动搅拌车
推荐产品

4.0方全自动搅拌车

3.5方C款平口搅拌车
推荐产品

3.5方C款平口搅拌车

4方同步旋转全自动搅拌车
推荐产品

4方同步旋转全自动搅拌车

4吨C
推荐产品

4吨C

2方后置驾驶室6165con登录平台
推荐产品

2方后置驾驶室6165con登录平台

3.5A款方全自动搅拌车
推荐产品

3.5A款方全自动搅拌车

6.5方6165con登录平台
推荐产品

6.5方6165con登录平台

1.8方平口搅拌车
推荐产品

1.8方平口搅拌车

2.6方平口搅拌车
推荐产品

2.6方平口搅拌车

3.5方C款6165con登录平台
推荐产品

3.5方C款6165con登录平台