6165con登录平台

欢迎光临山汽集团企业官网!
400-879-1999
在线购机
点击拨打服务热线:400-879-1999
您现在所在的位置: 6165con登录平台> 6165con登录平台常识 > 行业资讯 >
站内搜索
6165con登录平台常识
关于山汽

联系人:刘老师

电话:400-879-1999

企业:山东山汽工程机械(集团)有限企业

地址:山东省莱州市206国道与308省道交叉口东南50米

混凝土搅拌车罐体的维护应该注意什么?

所属分类:行业资讯 发布时间:2020-10-14 来源:/ 浏览量:18

一、作为一台混凝土搅拌机,首先要对混凝土搅拌机的箱体进行维护,并使用新的混凝土搅拌机将箱体支架实时固定在底盘框架附近。每次在运输混凝土并进入清洗槽后,都须知道混凝土容易与钢筋粘结。
1、 As a concrete mixer, it is necessary to maintain the box of the concrete mixer first, and use the new concrete mixer to fix the box bracket near the chassis frame in real time. Every time after transporting the concrete and entering the cleaning tank, it is necessary to know that the concrete is easy to bond with the reinforcement.
山东梁山环球重工专用车股份有限企业
Shandong Liangshan global heavy industry Special Vehicle Co., Ltd
二、出料的对称性是混凝土搅拌车的重要指标之一,直接影响施工质量。运输混凝土时,搅拌筒的转速应控制在2~5r/min。当混凝土坍落度较大,运输间隔较长时,出料前应快速移动搅拌筒5~10次,使内部混凝土充分搅拌,大大提高出料的对称性。如果混凝过程中失水,应在施工现场加水进行调解和充分搅拌。虽然这种环境应该停止,混凝土的质量将无法保证。有些用户在运输过程中不注意速度控制,过快会增加油耗,过小会造成混凝土离析。因此,搅拌筒的转速应严格按照资质要求进行控制,以提高混凝土的运输质量。
6165con登录平台
2、 The symmetry of discharging is one of the important indexes of concrete mixer truck, which directly affects the construction quality. When transporting concrete, the speed of mixing drum should be controlled at 2 ~ 5R / min. When the slump of concrete is large and the transportation interval is long, the mixing drum should be moved 5 ~ 10 times before discharging to fully mix the internal concrete and greatly improve the symmetry of discharge. In case of water loss in the process of coagulation, water shall be added to the construction site for mediation and full mixing. Although this environment should stop, the quality of concrete will not be guaranteed. Some users do not pay attention to the speed control in the transportation process, too fast will increase fuel consumption, too small will cause concrete segregation. Therefore, the rotation speed of mixing drum should be controlled strictly according to the qualification requirements to improve the transportation quality of concrete.
三、混凝土的至高不能高于储罐的至大容积,因为混凝土的密度因强度等级的不同而不同。高强混凝土一般具有较高的密度,相同的体积对汽车不利。输送混凝土的能力、质量和坍落度应符合车辆操作手册的规定,并应实时加注润滑油。
3、 The maximum height of concrete cannot be higher than the maximum volume of the tank, because the density of concrete varies with the strength grade. High strength concrete generally has high density, the same volume is not good for cars. The capacity, quality and slump of concrete conveying shall meet the requirements of vehicle operation manual, and lubricating oil shall be added in real time.
四、混凝土搅拌车停在露天时,装载前应先将搅拌筒卸去旋转,把水泥罐中的水放掉,以保证运输混凝土的质量。
4、 When the concrete mixer truck is parked in the open air, the mixing drum shall be removed and rotated before loading, and the water in the cement tank shall be drained to ensure the quality of concrete transported.
五、在高速公路上行驶时,应将卸料槽降至很低位置,随车身一起转移至垂直位置,并用锁紧装置将卸料槽锁紧在车架上,以防因不安全而晃动,造成伤害和事故,影响其他车辆的运行。如果梯子状况不好,会损坏油轮的油舱轴。
5、 When driving on the expressway, the discharge chute should be lowered to a very low position and transferred to the vertical position along with the vehicle body, and the discharge chute should be locked on the frame with the locking device, so as to avoid shaking due to insecurity, causing injuries and accidents, and affecting the operation of other vehicles. If the ladder is not in good condition, the oil tank shaft of the tanker will be damaged.
六、卸料前,如果发现水分蒸发,坍落度偏低不能饱满。当用户需要时,可在搅拌筒中适当加水,然后根据进料偏差,以6~10转/分钟的速度旋转30圈后,即可出料。
6、 Before unloading, if water evaporation is found, the slump is too low to be full. When the user needs, add water properly in the mixing drum, and then rotate 30 times at the speed of 6 ~ 10 RPM according to the feed deviation, and then the material can be discharged.
七、混凝土搅拌车在运输混凝土过程中不得将搅拌筒含动,以免出现混凝土离析现象。
7、 The concrete mixer truck shall not move the mixing drum in the process of transporting concrete, so as to avoid concrete segregation.
上面的内容就是今天小编给大家先容的内容了,大家真诚为您提供6165con登录平台服务,您的满意就是大家的责任,欢迎在网站下方留言:
The above content is the content introduced to you today. We sincerely provide automatic concrete mixer service for you. Your satisfaction is our responsibility. Welcome to leave a message at the bottom of the website:
热门产品 / HOT PRODUCT
3.5吨地下室
推荐产品

3.5吨地下室

4.0方6165con登录平台
推荐产品

4.0方6165con登录平台

5.5方全自动搅拌车
推荐产品

5.5方全自动搅拌车

3.5方A款6165con登录平台
推荐产品

3.5方A款6165con登录平台

6165con登录平台
推荐产品

6165con登录平台

3.5方A款6165con登录平台
推荐产品

3.5方A款6165con登录平台

2.6方同步旋转全自动搅拌车
推荐产品

2.6方同步旋转全自动搅拌车

3.5吨C款
推荐产品

3.5吨C款

4方同步旋转全自动搅拌车
推荐产品

4方同步旋转全自动搅拌车

4.0方全自动搅拌车
推荐产品

4.0方全自动搅拌车

2方后置驾驶室6165con登录平台
推荐产品

2方后置驾驶室6165con登录平台

3.5方D款平口搅拌车
推荐产品

3.5方D款平口搅拌车

6.5方6165con登录平台
推荐产品

6.5方6165con登录平台

棉花叉
推荐产品

棉花叉

下倾翻
推荐产品

下倾翻

铲斗内收
推荐产品

铲斗内收

4吨B
推荐产品

4吨B

1.2方全自动搅拌车
推荐产品

1.2方全自动搅拌车

1.8方平口搅拌车
推荐产品

1.8方平口搅拌车

2.6方平口搅拌车
推荐产品

2.6方平口搅拌车